A Techno-Environmental and Energy Efficiency Investigation of Marine Dual-Fuel Engines

Year 2023, Volume: 12 Issue: 2, 128 - 141, 30.06.2023

Mehmet Akman

https://doi.org/10.33714/masteb.1247489

Cited By: 3

Abstract

The ship-based greenhouse gas emissions along with the volumetric growth in maritime transportation have increased significantly over the years. International Maritime Organization (IMO) has tightened the emission limits by putting new regulations into effect to overcome the environmental impacts and therefore, the maritime industry has focused on energy-efficient ship design and operation, recently. Regarding the latest developments, dual-fuel engines operated with different fuels have been installed and new technological developments in emission control have been implemented onboard ships. In this context, the selection of engine systems where there are many options available has been a substantial problem in the design process of a ship, recently. The latest marine engines are capable of operating with various types of fuels at different emission control modes, therefore, energy efficiency and emission performance of the prime movers should be analyzed in detail. In this study, VLSFO, methanol, LPG, LNG and MDO-fueled engines with the same power output are investigated and the NOX reduction device integrated engines’ technical specifications are compared. Then, the selected dual-fuel engines are thermodynamically analyzed and the environmental impacts are evaluated under different engine loads, Tier II, Tier III modes and ambient conditions. Moreover, EEDI calculations are conducted under the case study of powering a medium-range tanker and engine options are evaluated in terms of energy efficiency. Finally, a sensitivity analysis of engine performance is carried and the results are validated. According to the results, the energy efficiency of the ship can be increased by up to 20% by selecting the LNG-fueled engine as the prime mover while it requires more space and equipment compared to other engines.

Keywords

Energy efficiency, Emission control, Marine engine, Dual-fuel, EEDI

References

• ABS. (2020). ABS Advisory on NOx Tier III Compliance.
• Akman, M., & Ergin, S. (2019). An investigation of marine waste heat recovery system based on organic Rankine cycle under various engine operating conditions. Proceedings of the Institution of Mechanical Engineers Part M: Journal of Engineering for the Maritime Environment, 233(2), 586–601. https://doi.org/10.1177/1475090218770947
• Akman, M., & Ergin, S. (2021). Energy-efficient shipping: Thermo-environmental analysis of an organic Rankine cycle waste heat recovery system utilizing exhaust gas from a dual-fuel engine. The 34th Asian-Pacific Technical Exchange and Advisory Meeting on Marine Structures, Türkiye. pp. 329-335.
• Akman, M., & Ergin, S. (2022). Greener shipping: An investigation of an ORC-based waste heat recovery system for a methanol-fueled marine engine. A.Yücel ODABAŞI Colloquium Series 4th International Meeting - Ship Design & Optimization and Energy Efficient Devices for Fuel Economy, Türkiye, pp. 81-86.
• Bureau Veritas. (2022). Alternative Propulsion and Future Fuels. https://marine-offshore.bureauveritas.com/sustainability/alternative-propulsion-and-future-fuels
• Dere, C., Zincir, B., Inal, O. B., & Deniz, C. (2022). Investigation of the adverse effects of slow steaming operations for ships. Proceedings of the Institution of Mechanical Engineers, Part M: Journal of Engineering for the Maritime Environment, 236(4), 1069–1081. https://doi.org/10.1177/14750902221074191
• DNV. (2022). Maritime Forecast 2050. https://www.dnv.com/maritime/insights/topics/MRV-and-DCS/index.html
• Elkafas, A., Rivarolo, M., & Massardo, A. F. (2022). Assessment Of Alternative Marine Fuels from Environmental, Technical, and Economic Perspectives Onboard Ultra Large Container Ship. International Journal of Maritime Engineering, 164(A2), 125–134. https://doi.org/10.5750/ijme.v164ia2.768
• EPA. (2014). Emission Factors for Greenhouse Gas Inventories. http://www.epa.gov/ghgreporting/reporters/subpart/c.html
• Evans, J. H. (1959). Basic design concepts. Journal of the American Society for Naval Engineers, 71(4), 671-678. https://doi.org/10.1111/j.1559-3584.1959.tb01836.x
• Feng, S., Li, Z., Shen, B., Yuan, P., Ma, J., Wang, Z., & Kong, W. (2022). An overview of the deactivation mechanism and modification methods of the SCR catalysts for denitration from marine engine exhaust. Journal of Environmental Management, 317, 115457. https://doi.org/10.1016/j.jenvman.2022.115457
• Feng, S., Xu, S., Yuan, P., Xing, Y., Shen, B., Li, Z., Zhang, C., Wang, X., Wang, Z., Ma, J., & Kong, W. (2022). The impact of alternative fuels on ship engine emissions and aftertreatment systems: A review. Catalysts, 12(2), 138. https://doi.org/10.3390/catal12020138
• Garcia, L., Gehle, S., & Schakel, J. (2014). Impact of low load operation in modern low speed 2-stroke diesel engines on cylinder liner wear caused by increased acid condensation. Journal of the JIME, 49(1), 100-106.
• Grljušic, M., Medica, V., & Radica, G. (2015). Calculation of efficiencies of a ship power plant operating with waste heat recovery through combined heat and power production. Energies, 8(5), 4273–4299. https://doi.org/10.3390/en8054273
• Güler, E., & Ergin, S. (2021). An investigation on the solvent based carbon capture and storage system by process modeling and comparisons with another carbon control methods for different ships. International Journal of Greenhouse Gas Control, 110. https://doi.org/10.1016/j.ijggc.2021.103438
• Han, F., Wang, Z., Ji, Y., Li, W., & Sundén, B. (2019). Energy analysis and multi-objective optimization of waste heat and cold energy recovery process in LNG-fueled vessels based on a triple organic Rankine cycle. Energy Conversion and Management, 195, 561–572. https://doi.org/10.1016/j.enconman.2019.05.040
• Harris, R., Conlan, M., & Simon, J. (2022a). Review of LNG and Methanol Marine Fuel Options. IGP Energy. https://igpmethanol.com/igpmwp/wp-content/uploads/2022/03/Review-of-LNG-and-Methanol-Marine-Fuel-Options-Exec-Summ-03-10-2022.pdf
• Harris, R., Conlan, M., & Simon, J. (2022b). Summary of LNG and Methanol Marine Fuel Options. https://igpmethanol.com/2022/03/21/summary-of-lng-and-methanol-marine-fuel-options/
• Huang, J., Fan, H., Xu, X., & Liu, Z. (2022). Life Cycle Greenhouse Gas Emission Assessment for Using Alternative Marine Fuels: A Very Large Crude Carrier (VLCC) Case Study. Journal of Marine Science and Engineering, 10(12), 1969. https://doi.org/10.3390/jmse10121969
• IMO. (2012). Guidelines for Calculation of Reference Lines for Use with The Energy Efficiency Design Index -MEPC.215(63).
• IMO. (2013). MARPOL Annex VI. https://www.imo.org/en/ourwork/environment/pages/air-pollution.aspx
• IMO. (2019). Emission Control Areas (ECAs). https://www.imo.org/en/OurWork/Environment/Pages/Emission-Control-Areas-(ECAs)-designated-under-regulation-13-of-MARPOL-Annex-VI-(NOx-emission-control).aspx
• IMO. (2020). Fourth IMO GHG Study 2020 Executive Summary.
• IMO. (2021). Marine Environment Protection Committee (MEPC 76). https://www.imo.org/en/MediaCentre/MeetingSummaries/Pages/MEPC76meetingsummary.aspx
• JASNAOE. (1980). On the optimization of aft-part of fine hull forms (first report).
• Johnson, H., & Styhre, L. (2015). Increased energy efficiency in short sea shipping through decreased time in port. Transportation Research Part A: Policy and Practice, 71, 167–178. https://doi.org/10.1016/j.tra.2014.11.008
• Konur, O., Yuksel, O., Korkmaz, S. A., Colpan, C. O., Saatcioglu, O. Y., & Muslu, I. (2022). Thermal design and analysis of an organic Rankine cycle system utilizing the main engine and cargo oil pump turbine based waste heats in a large tanker ship. Journal of Cleaner Production, 368, 133230. https://doi.org/10.1016/j.jclepro.2022.133230
• Köseoğlu, M. C., Akman, M., & Çınar, F. (2021). Environmental cost-benefit analysis of cold ironing systems in green container ports for 2020-2030: A case study in Turkey. Proceedings of the 2nd International Congress on Ship and Marine Technology, Türkiye. pp. 13-22.
• Law, L. C., Foscoli, B., Mastorakos, E., & Evans, S. (2021). A comparison of alternative fuels for shipping in terms of lifecycle energy and cost. Energies, 14(24), 8502. https://doi.org/10.3390/en14248502
• Law, L. C., Mastorakos, E., & Evans, S. (2022). Estimates of the decarbonization potential of alternative fuels for shipping as a function of vessel type, cargo, and voyage. Energies, 15(20), 7468. https://doi.org/10.3390/en15207468
• Liu, L., Tang, Y., & Liu, D. (2022). Investigation of future low-carbon and zero-carbon fuels for marine engines from the view of thermal efficiency. Energy Reports, 8, 6150–6160. https://doi.org/10.1016/j.egyr.2022.04.058
• Livaniou, S., Chatzistelios, G., Lyridis, D. v., & Bellos, E. (2022). LNG vs. MDO in Marine Fuel Emissions Tracking. Sustainability (Switzerland), 14(7), 3860. https://doi.org/10.3390/su14073860
• Lu, D., Theotokatos, G., Zhang, J., Zeng, H., & Cui, K. (2022). Comparative Assessment and Parametric Optimisation of Large Marine Two-Stroke Engines with Exhaust Gas Recirculation and Alternative Turbocharging Systems. Journal of Marine Science and Engineering, 10(3), 351. https://doi.org/10.3390/jmse10030351
• MAN. (2014). Using Methanol Fuel in the MAN B&W ME-LGI Series. https://www.mandieselturbo.com/docs/default-source/shopwaredocuments/using-methanol-fuel-in-the-man-b-w-me-lgi-series.pdf
• MAN. (2015). Tier III considerations. https://safety4sea.com/wp-content/uploads/2015/01/5.4-D.Tsalapatis-COSTAMARE.pdf
• MAN. (2016a). MAN Alpha Unique Kappel Propellers – Radical Fuel Savings.
• MAN. (2016b). MAN B&W G-Engines. https://www.mandieselturbo.com/docs/default-source/shopwaredocuments/man-b-w-g-engines-green-ultra-long-stroke-engines15fbf9a55cda459c8d405548eea8e7e1.pdf?sfvrsn=3
• MAN. (2016c). Medium-speed engines for cleaner air. https://www.man-es.com/docs/default-source/document-sync/technology-for-ecology-eng.pdf?sfvrsn=bc606d0a_0
• MAN. (2021a). Managing methane slip. https://www.man-es.com/campaigns/download-Q1-2023/Download/managing-methane-slip/d34a34a1-cc03-4d99-a4e1-30385cf12518/Managing-Methan-Slip
• MAN. (2021b). Propulsion trends in tankers. https://www.man-es.com/docs/default-source/marine/tools/propulsion-trends-in-tankers_5510-0031-03ppr.pdf?sfvrsn=399654ef_4
• MAN. (2022a). Emission project guide MAN B&W Two-stroke marine engines. www.marine.man-es.com
• MAN. (2022b). Technical Documentation Project Guide. https://man-es.com/applications/projectguides/2stroke/content/printed/G50ME-C9_6.pdf
• MAN. (2023). CEAS engine calculations. https://www.man-es.com/marine/products/planning-tools-and-downloads/ceas-engine-calculations
• MEPC.308(73). (2018). Guidelines on The Method of Calculation of The Attained Energy Efficiency Design Index (EEDI) for New Ships.
• Napolitano, P., Liotta, L. F., Guido, C., Tornatore, C., Pantaleo, G., la Parola, V., & Beatrice, C. (2022). Insights of selective catalytic reduction technology for nitrogen oxides control in marine engine applications. Catalysts, 12(10), 1191. https://doi.org/10.3390/catal12101191
• Perčić, M., Vladimir, N., & Fan, A. (2021). Techno-economic assessment of alternative marine fuels for inland shipping in Croatia. Renewable and Sustainable Energy Reviews, 148, 111363. https://doi.org/10.1016/j.rser.2021.111363
• Singh, D. V., & Pedersen, E. (2016). A review of waste heat recovery technologies for maritime applications. Energy Conversion and Management, 111, 315–328. https://doi.org/10.1016/j.enconman.2015.12.073
• Turan, B. I., & Akman, M. (2021). Modeling and comparison of Bodrum Gulets’ hull forms with round and transom sterns. Journal of ETA Maritime Science, 9(2), 120–129. https://doi.org/10.4274/jems.2021.09327
• Vidović, T., Šimunović, J., Radica, G., & Penga, Ž. (2023). Systematic overview of newly available technologies in the green maritime sector. Energies, 16(2), 641. https://doi.org/10.3390/en16020641
• Wang, K., Yan, X., Yuan, Y., Jiang, X., Lin, X., & Negenborn, R. R. (2018). Dynamic optimization of ship energy efficiency considering time-varying environmental factors. Transportation Research Part D: Transport and Environment, 62, 685–698. https://doi.org/10.1016/j.trd.2018.04.005
• Wärtsilä. (2022). Rotor Sail Technology. https://www.wartsila.com/marine/products/propulsors-and-gears/energy-saving-technology/rotor-sail
• Woodyard, D. (2004). Gas-diesel and dual-fuel engines (pp. 48–63). In Woodyard, D. (Ed.), Pounder’s Marine Diesel Engines and Gas Turbines (8th ed.). Butterworth-Heinemann. https://doi.org/10.1016/B978-075065846-1/50003-1
• Zou, J., & Yang, B. (2023). Evaluation of alternative marine fuels from dual perspectives considering multiple vessel sizes. Transportation Research Part D: Transport and Environment, 115, 103583. https://doi.org/10.1016/j.trd.2022.103583