Araştırma Makalesi
BibTex RIS Kaynak Göster

Determination of the effect of different gravity methods on the removal of ash and sulfur from Arguvan lignite

Yıl 2021, , 64 - 81, 31.08.2021

Aydan Aksoğan Korkmaz

https://doi.org/10.46740/alku.931712
Cited By: 1

Öz

This study, it is aimed to find out the beneficiation of Malatya-Arguvan lignite by gravity methods. First of all, the washability of lignite has been investigated with sink-float experiments. It has been determined that lignite washability from washing curves is generally difficult but may be possible with controlled washing at a density of 1.68 g /cm3. Then, to remove ash and sulfur from lignite by shaking table, spiral and Falcon concentrator tests were conducted. Clean coals are obtained from all other methods except Falcon were found to decrease in ash and sulfur content and increase in calorific value. Clean coals with the lowest ash and sulfur content were obtained with a spiral concentrator. Reichert spiral results showed that the ash content decreased from the lignite of 37.77% to 26.50% and the sulfur content from 3.85% to 2.08%. The calorific value increased from 2576 kcal/kg to 4590 kcal/kg. Arguvan lignite has very limited usage due to lower calorific value, high ash and sulfur content. Although enrichment has been carried out, it has been concluded that lignite needs to be further improved by using different methods.

Anahtar Kelimeler

Lignite Falcon concentrator Reichert spiral Shaking table Sink-Float tests

Destekleyen Kurum

İnönü Üniversitesi BAP

Proje Numarası

2015/34

Teşekkür

The research presented in this publication was funded by the Inonu University Scientific Research Projects (BAP) unit (Project No. 2015/34).

Kaynakça

  • [1] Ceylan, K. and Küçük, M.Z. (2004), “Effectiveness of the dense medium and the froth flotation methods in cleaning some Turkish lignites”, Energy Conversion and Management 45, 1407-1418.
  • [1] Ceylan, K. and Küçük, M.Z. (2004), “Effectiveness of the dense medium and the froth flotation methods in cleaning some Turkish lignites”, Energy Conversion and Management 45, 1407-1418.
  • [2] Demir, U. (2017), “Characterization and desulfurization possibilities of high sulfur Gediz-Turkey coal”, Journal of Environmental Science and Engineering A 6, 31-38.
  • [2] Demir, U. (2017), “Characterization and desulfurization possibilities of high sulfur Gediz-Turkey coal”, Journal of Environmental Science and Engineering A 6, 31-38.
  • [3] Meshram, P., Purohit, B.K., Sinha, M.K., Sahu, S.K. and Pandey, B.D. (2015), “Demineralization of low grade coal – A review”, Renewable and Sustainable Energy Reviews 41, 745-761.
  • [3] Meshram, P., Purohit, B.K., Sinha, M.K., Sahu, S.K. and Pandey, B.D. (2015), “Demineralization of low grade coal – A review”, Renewable and Sustainable Energy Reviews 41, 745-761.
  • [4] Cheng, W., Yang, R., Zhang, Q., Luo, B. and Jia, Y. (2018), “Washability and distribution behaviors of trace elements of a high-sulfur coal, SW Guizhou, China”, Minerals 8.59, 1-15.
  • [4] Cheng, W., Yang, R., Zhang, Q., Luo, B. and Jia, Y. (2018), “Washability and distribution behaviors of trace elements of a high-sulfur coal, SW Guizhou, China”, Minerals 8.59, 1-15.
  • [5] Sivrikaya, O. (2014), “Cleaning study of a low-rank lignite with DMS, Reichert spiral and flotation”, Fuel 119, 252-258.
  • [5] Sivrikaya, O. (2014), “Cleaning study of a low-rank lignite with DMS, Reichert spiral and flotation”, Fuel 119, 252-258.
  • [6] Zhang, Q., Tian, Y., Qui, Y., Cao, J. and Xiao, T. (2011), “Study on the washability of the Kaitai coal, Guizhou Province China”, Fuel Processing Technology 92, 692-698.
  • [6] Zhang, Q., Tian, Y., Qui, Y., Cao, J. and Xiao, T. (2011), “Study on the washability of the Kaitai coal, Guizhou Province China”, Fuel Processing Technology 92, 692-698.
  • [7] Rahman, M., Pudasainee, D. and Gupta, R. (2017), “Review on chemical upgrading of coal: Production processes, potential applications and recent developments”, Fuel Processing Technology 158, 35-56.
  • [7] Rahman, M., Pudasainee, D. and Gupta, R. (2017), “Review on chemical upgrading of coal: Production processes, potential applications and recent developments”, Fuel Processing Technology 158, 35-56.
  • [8] Falconer, A. (2003), “Gravity separation: Old technique/New methods”, Physical Separation in Science and Engineering 12.1, 31-48.
  • [8] Falconer, A. (2003), “Gravity separation: Old technique/New methods”, Physical Separation in Science and Engineering 12.1, 31-48.
  • [9] Lee, S-J., Cho, H-C., and Kwon, J-H. (2012), “Beneficiation of coal pond ash by physical separation techniques”, Journal of Environmental Management 104, 77-84.
  • [9] Lee, S-J., Cho, H-C., and Kwon, J-H. (2012), “Beneficiation of coal pond ash by physical separation techniques”, Journal of Environmental Management 104, 77-84.
  • [10] İbrahim, S.S., Anadoly, B.E., Farahat, M.M., Selim, A.Q., and Menshawy, A.H. (2014), “Separation of pyritic sulfur from Egyptian coal using Falcon concentrator”, Particulate Science and Technology 32, 588-594.
  • [10] İbrahim, S.S., Anadoly, B.E., Farahat, M.M., Selim, A.Q., and Menshawy, A.H. (2014), “Separation of pyritic sulfur from Egyptian coal using Falcon concentrator”, Particulate Science and Technology 32, 588-594.
  • [11] Xia, W., Xie, G. and Peng, Y. (2015), “Recent advances in beneficiation for low rank coals”, Powder Technology 277, 206-221.
  • [11] Xia, W., Xie, G. and Peng, Y. (2015), “Recent advances in beneficiation for low rank coals”, Powder Technology 277, 206-221.
  • [12] Özgen, S., Malkoç, Ö., Doğancik, C., Sabah, E. and Oruç Şapçi, F. (2011), “Optimization of a Multi Gravity Separator to produce clean coal from Turkish lignite fine coal tailings”, Fuel 90.4, 1549-1555.
  • [12] Özgen, S., Malkoç, Ö., Doğancik, C., Sabah, E. and Oruç Şapçi, F. (2011), “Optimization of a Multi Gravity Separator to produce clean coal from Turkish lignite fine coal tailings”, Fuel 90.4, 1549-1555.
  • [13] Honaker, R.Q., Wang, D. and Ho, K. (1996), “Application of the Falcon concentrator for fine coal cleaning”, Minerals Engineering 9.11, 1143-1156.
  • [13] Honaker, R.Q., Wang, D. and Ho, K. (1996), “Application of the Falcon concentrator for fine coal cleaning”, Minerals Engineering 9.11, 1143-1156.
  • [14] Honaker, R.Q., Paul, B.C., Wang, D. and Ho, K. Enhanced gravity separation: an alternative to flotation. Proceedings of high efficiency coal preparation: an international symposium. Colorado (USA): 1995; 70-80.
  • [14] Honaker, R.Q., Paul, B.C., Wang, D. and Ho, K. Enhanced gravity separation: an alternative to flotation. Proceedings of high efficiency coal preparation: an international symposium. Colorado (USA): 1995; 70-80.
  • [15] Rath, R.K., Singh, R. and Bhattacharya, K.K. Processing of coal waste by enhanced gravity separation and froth flotation. Proceedings of International Conference on Coal and Coke. 2011 April 7-8; Jamshedpur (India): 2011; 1-8.
  • [15] Rath, R.K., Singh, R. and Bhattacharya, K.K. Processing of coal waste by enhanced gravity separation and froth flotation. Proceedings of International Conference on Coal and Coke. 2011 April 7-8; Jamshedpur (India): 2011; 1-8.
  • [16] Das, A., Sarkar, B., Ari, V. and Roy, S. (2010), “Efficient recovery of combustibles from coking coal fines”, Mineral Processing Extraction Metallurgy Rev. 31, 236-249.
  • [16] Das, A., Sarkar, B., Ari, V. and Roy, S. (2010), “Efficient recovery of combustibles from coking coal fines”, Mineral Processing Extraction Metallurgy Rev. 31, 236-249.
  • [17] Özbakir, O., Koltka, S. and Sabah, E. (2017), “Modeling and optimization of fine coal beneficiation by hydrocyclone and multi-gravity separation to produce fine lignite clean coal”, Particulate Science and Technology 35.6, 712-722.
  • [17] Özbakir, O., Koltka, S. and Sabah, E. (2017), “Modeling and optimization of fine coal beneficiation by hydrocyclone and multi-gravity separation to produce fine lignite clean coal”, Particulate Science and Technology 35.6, 712-722.
  • [18] Şahinoğlu, E. (2018), “Cleaning of high pyritic sulfur fine coal via flotation”, Advanced Powder Technology 29, 1703-1712.
  • [18] Şahinoğlu, E. (2018), “Cleaning of high pyritic sulfur fine coal via flotation”, Advanced Powder Technology 29, 1703-1712.
  • [19] Ghadyani, A., Noaparast, M. and Tonkaboni, S.Z.S. (2018), “A study on the effects of ultrasonic irradiation as pretreatment method on high-ash coal flotation and kinetics”, International Journal of Coal Preparation and Utilization 38.7, 374-391.
  • [19] Ghadyani, A., Noaparast, M. and Tonkaboni, S.Z.S. (2018), “A study on the effects of ultrasonic irradiation as pretreatment method on high-ash coal flotation and kinetics”, International Journal of Coal Preparation and Utilization 38.7, 374-391.
  • [20] Peng, Y., Mao, Y., Xia, W. and Li, Y. (2018), “Ultrasonic flotation cleaning of high-ash lignite and its mechanism”, Fuel 220, 558-566.
  • [20] Peng, Y., Mao, Y., Xia, W. and Li, Y. (2018), “Ultrasonic flotation cleaning of high-ash lignite and its mechanism”, Fuel 220, 558-566.
  • [21] Özkan, S.G. (2017), “Further investigations on simultaneous ultrasonic coal flotation”, Minerals 7.177, 1-9.
  • [21] Özkan, S.G. (2017), “Further investigations on simultaneous ultrasonic coal flotation”, Minerals 7.177, 1-9.
  • [22] Elbeyli, İ.Y. and Pişkin, S. (2006), “Combustion and pyrolysis characteristics of Tunçbilek lignite”, Journal of Thermal Analysis and Calorimetry 83.3, 721-726.
  • [22] Elbeyli, İ.Y. and Pişkin, S. (2006), “Combustion and pyrolysis characteristics of Tunçbilek lignite”, Journal of Thermal Analysis and Calorimetry 83.3, 721-726.
  • [23] Feng, J., Li, W-Y. and Xie, K-C. (2006), “Thermal decomposition behaviors of lignite by pyrolysis-FTIR”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 28, 167-175.
  • [23] Feng, J., Li, W-Y. and Xie, K-C. (2006), “Thermal decomposition behaviors of lignite by pyrolysis-FTIR”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 28, 167-175.
  • [24] Lievens, C., Ci, D., Bai, Y., Ma, L., Zhang, R., Chen, Y.J., Gai, Q., Long, Y. and Guo, X. (2013), “A study of slow pyrolysis of one low rank coal via pyrolysis-GC/MS”, Fuel Processing Technology 116, 85-93.
  • [24] Lievens, C., Ci, D., Bai, Y., Ma, L., Zhang, R., Chen, Y.J., Gai, Q., Long, Y. and Guo, X. (2013), “A study of slow pyrolysis of one low rank coal via pyrolysis-GC/MS”, Fuel Processing Technology 116, 85-93.
  • [25] Abakay Temel, H., Majumder, A.K. (2016), “Investigation of the effectiveness of desliming and flotation in cleaning Malatya-Arguvan lignite”, Energy Sources, Part A: Recovery, Utilization and Environmental Effects 38, 1048-1054.
  • [25] Abakay Temel, H., Majumder, A.K. (2016), “Investigation of the effectiveness of desliming and flotation in cleaning Malatya-Arguvan lignite”, Energy Sources, Part A: Recovery, Utilization and Environmental Effects 38, 1048-1054.
  • [26] Aksoğan Korkmaz, A. and Bentli, İ. (2017), “Determination of washability characteristics of Arguvan-Malatya lignite by different washability index methods”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 39.14, 1572-1580.
  • [26] Aksoğan Korkmaz, A. and Bentli, İ. (2017), “Determination of washability characteristics of Arguvan-Malatya lignite by different washability index methods”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 39.14, 1572-1580.
  • [27] Birinci, M. Determination of washability characteristics of Parcikan (Malatya) lignite. Proceedings of the 17th International Coal Preparation Congress. 2013 October 1-6; İstanbul (Turkey): 2013; 189-192.
  • [27] Birinci, M. Determination of washability characteristics of Parcikan (Malatya) lignite. Proceedings of the 17th International Coal Preparation Congress. 2013 October 1-6; İstanbul (Turkey): 2013; 189-192.
  • [28] Abakay Temel, H., Majumder, A.K. and Bakir, Y. (2015), “An assessment of Malatya-Arguvan lignite and Southeastern Anatolia region lignites (Turkey)”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 37, 1202-1209.
  • [28] Abakay Temel, H., Majumder, A.K. and Bakir, Y. (2015), “An assessment of Malatya-Arguvan lignite and Southeastern Anatolia region lignites (Turkey)”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 37, 1202-1209.
  • [29] Ünlü, M. The washability characteristics and washing possibilities of Turkish lignites. Proc. 3rd. International Mineral Processing Symposium. 1990 September 11-13; İstanbul (Turkey): 1990; 274-286.
  • [29] Ünlü, M. The washability characteristics and washing possibilities of Turkish lignites. Proc. 3rd. International Mineral Processing Symposium. 1990 September 11-13; İstanbul (Turkey): 1990; 274-286.
  • [30] Wills, B.A. (2007), Mineral Processing Technology 4thEd. Pergamon Press., NewYork, USA.
  • [30] Wills, B.A. (2007), Mineral Processing Technology 4thEd. Pergamon Press., NewYork, USA.
  • [31] Laskowski, J.S. (2001), Coal Flotation and Fine Coal Utilization. Elsevier, Canada.
  • [31] Laskowski, J.S. (2001), Coal Flotation and Fine Coal Utilization. Elsevier, Canada.
  • [32] Altun, N.E. and Hiçyilmaz, C. Evaluation of Alpagut-Dodurga waste coals. Proceedings of the 13th Turkish Coal Congress. 2002 May 29-31; Zonguldak (Turkey): 2002; 113-123.
  • [32] Altun, N.E. and Hiçyilmaz, C. Evaluation of Alpagut-Dodurga waste coals. Proceedings of the 13th Turkish Coal Congress. 2002 May 29-31; Zonguldak (Turkey): 2002; 113-123.
  • [33] Öney, Ö., Tanriverdi, M. and Çiçek, T. Enrichment of Zonguldak fine coals with spiral separator. Proceedings of the 19th Turkish Coal Congress. 2014 May 21-23; Zonguldak (Turkey): 2014; 217-225.
  • [33] Öney, Ö., Tanriverdi, M. and Çiçek, T. Enrichment of Zonguldak fine coals with spiral separator. Proceedings of the 19th Turkish Coal Congress. 2014 May 21-23; Zonguldak (Turkey): 2014; 217-225.
  • [34] Can, M.F., Özgen, S. and Sabah, E. A study to recover coal from Turkish lignite fine coal tailings: comparison of Falcon concentrator and multi gravity separator. International Pittsburgh Coal Conference. 2010 October 11-14; İstanbul (Turkey): 2010; 1897-1912.
  • [34] Can, M.F., Özgen, S. and Sabah, E. A study to recover coal from Turkish lignite fine coal tailings: comparison of Falcon concentrator and multi gravity separator. International Pittsburgh Coal Conference. 2010 October 11-14; İstanbul (Turkey): 2010; 1897-1912.
  • [35] Oruç, F., Özgen, S. and Sabah, E. (2010), “An enhanced-gravity method to recover ultra-fine coal from tailings: Falcon concentrator”, Fuel 89, 2433-2437.
  • [35] Oruç, F., Özgen, S. and Sabah, E. (2010), “An enhanced-gravity method to recover ultra-fine coal from tailings: Falcon concentrator”, Fuel 89, 2433-2437.
  • [36] Boylu, F. (2013), “Modeling of free and hindered settling conditions for fine coal beneficiation through a Falcon concentrator”, International Journal of Coal Preparation and Utilization 33, 277-289.
  • [36] Boylu, F. (2013), “Modeling of free and hindered settling conditions for fine coal beneficiation through a Falcon concentrator”, International Journal of Coal Preparation and Utilization 33, 277-289.
  • [37] Boylu, F. (2014), “Autogenous medium fine coal washing through Falcon concentrator”, Separation Science and Technology 49, 627-633.
  • [37] Boylu, F. (2014), “Autogenous medium fine coal washing through Falcon concentrator”, Separation Science and Technology 49, 627-633.
  • [38] Zhu, X., Tao, Y and Sun, Q. (2017a), “Separation of flocculated ultrafine coal by enhanced gravity separator”, Particulate Science and Technology 35.4, 393-399.
  • [38] Zhu, X., Tao, Y and Sun, Q. (2017a), “Separation of flocculated ultrafine coal by enhanced gravity separator”, Particulate Science and Technology 35.4, 393-399.
  • [39] Honaker, R.Q. (1998), “High capacity fine coal cleaning using an enhanced gravity concentrator”, Minerals Engineering 11.12, 1191-1199.
  • [39] Honaker, R.Q. (1998), “High capacity fine coal cleaning using an enhanced gravity concentrator”, Minerals Engineering 11.12, 1191-1199.
  • [40] Honaker, R.Q., Singh, N. and Govindarajan, B. (2000), “Application of dense-medium in an enhanced gravity separator for fine coal cleaning”, Minerals Engineering 13.4, 415-427.
  • [40] Honaker, R.Q., Singh, N. and Govindarajan, B. (2000), “Application of dense-medium in an enhanced gravity separator for fine coal cleaning”, Minerals Engineering 13.4, 415-427.
  • [41] Tao, Y., Luo, Z., Zhao, Y. and Tao, D. (2006), “Experimental research on desulfurization of fine coal using an enhanced centrifugal gravity separator”, J.China Univ. of Mining and Technology 16.4, 399-403.
  • [41] Tao, Y., Luo, Z., Zhao, Y. and Tao, D. (2006), “Experimental research on desulfurization of fine coal using an enhanced centrifugal gravity separator”, J.China Univ. of Mining and Technology 16.4, 399-403.
  • [42] Zhu, X., Tao, Y., Sun, Q. and Man, Z. (2017b), “Enrichment and migration regularity of fine coal particles in enhanced gravity concentrator”, International Journal of Mineral Processing 163, 48-54.
  • [42] Zhu, X., Tao, Y., Sun, Q. and Man, Z. (2017b), “Enrichment and migration regularity of fine coal particles in enhanced gravity concentrator”, International Journal of Mineral Processing 163, 48-54.
  • [43] Zhu, X., Tao, Y., Sun, Q. and Man, Z. (2017c), “The low efficiency of lignite separation by an enhanced gravity concentrator”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 39.8, 835-842.
  • [43] Zhu, X., Tao, Y., Sun, Q. and Man, Z. (2017c), “The low efficiency of lignite separation by an enhanced gravity concentrator”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 39.8, 835-842.
  • [44] Zhang, L., Tao, Y., Yang, L. and Man, Z. (2017), “Spatial distribution of fine high-sulfur lean coal in enhanced gravity field”, Energy Sources, Part A: Recovery, Utilization and Environmental Effects 39.22, 2098-2104.
  • [44] Zhang, L., Tao, Y., Yang, L. and Man, Z. (2017), “Spatial distribution of fine high-sulfur lean coal in enhanced gravity field”, Energy Sources, Part A: Recovery, Utilization and Environmental Effects 39.22, 2098-2104.

Arguvan linyitinden kül ve kükürt uzaklaştırılmasında farklı gravite yöntemlerinin etkisinin belirlenmesi

Yıl 2021, , 64 - 81, 31.08.2021

Aydan Aksoğan Korkmaz

https://doi.org/10.46740/alku.931712
Cited By: 1

Öz

Bu çalışmada gravite yöntemleriyle Malatya-Arguvan linyitinin zenginleştirilmesi amaçlanmıştır. Öncelikle, yüzdürme-batırma deneyleriyle linyitin yıkanabilirliği araştırılmıştır. Yıkama eğrilerinden linyitin yıkanabilirliğinin genel olarak zor olduğu, 1,68 g/cm3 yoğunlukta kontrollü olarak yıkanabileceği belirlenmiştir. Daha sonra, linyitten kül ve kükürdü uzaklaştırmak için sallantılı masa, spiral ve Falcon konsantratör deneyleri yapılmıştır. Falcon hariç diğer tüm yöntemlerden elde edilen temiz kömürde kül ve kükürt içeriğinin azalmış, kalorifik değer ise artmıştır. En düşük kül ve kükürt içeriğine sahip olan temiz kömürler spiral konsantratör ile elde edilmiştir. Reichert spirali sonuçları linyitteki kül içeriğinin %37,77’den %26,50’ye ve kükürt içeriğinin ise %3,85’den %2,08’e azalmış olduğunu göstermiştir. Kalorifik değer 2576 kcal/kg’dan 4590 kcal/kg’a yükselmiştir. Düşük kalorifik değeri, yüksek kül ve kükürt içeriği yüzünden Arguvan linyiti sınırlı bir kullanıma sahiptir. Her ne kadar zenginleştirme gerçekleşse de, farklı yöntemler kullanılarak linyitin daha da iyileştirilmesi gerektiği sonucuna varılmıştır.

Anahtar Kelimeler

Linyit Falcon konsantratör Reichert spiral Sallantılı masa Yüzdürme-Batırma deneyleri

Proje Numarası

2015/34

Kaynakça

  • [1] Ceylan, K. and Küçük, M.Z. (2004), “Effectiveness of the dense medium and the froth flotation methods in cleaning some Turkish lignites”, Energy Conversion and Management 45, 1407-1418.
  • [1] Ceylan, K. and Küçük, M.Z. (2004), “Effectiveness of the dense medium and the froth flotation methods in cleaning some Turkish lignites”, Energy Conversion and Management 45, 1407-1418.
  • [2] Demir, U. (2017), “Characterization and desulfurization possibilities of high sulfur Gediz-Turkey coal”, Journal of Environmental Science and Engineering A 6, 31-38.
  • [2] Demir, U. (2017), “Characterization and desulfurization possibilities of high sulfur Gediz-Turkey coal”, Journal of Environmental Science and Engineering A 6, 31-38.
  • [3] Meshram, P., Purohit, B.K., Sinha, M.K., Sahu, S.K. and Pandey, B.D. (2015), “Demineralization of low grade coal – A review”, Renewable and Sustainable Energy Reviews 41, 745-761.
  • [3] Meshram, P., Purohit, B.K., Sinha, M.K., Sahu, S.K. and Pandey, B.D. (2015), “Demineralization of low grade coal – A review”, Renewable and Sustainable Energy Reviews 41, 745-761.
  • [4] Cheng, W., Yang, R., Zhang, Q., Luo, B. and Jia, Y. (2018), “Washability and distribution behaviors of trace elements of a high-sulfur coal, SW Guizhou, China”, Minerals 8.59, 1-15.
  • [4] Cheng, W., Yang, R., Zhang, Q., Luo, B. and Jia, Y. (2018), “Washability and distribution behaviors of trace elements of a high-sulfur coal, SW Guizhou, China”, Minerals 8.59, 1-15.
  • [5] Sivrikaya, O. (2014), “Cleaning study of a low-rank lignite with DMS, Reichert spiral and flotation”, Fuel 119, 252-258.
  • [5] Sivrikaya, O. (2014), “Cleaning study of a low-rank lignite with DMS, Reichert spiral and flotation”, Fuel 119, 252-258.
  • [6] Zhang, Q., Tian, Y., Qui, Y., Cao, J. and Xiao, T. (2011), “Study on the washability of the Kaitai coal, Guizhou Province China”, Fuel Processing Technology 92, 692-698.
  • [6] Zhang, Q., Tian, Y., Qui, Y., Cao, J. and Xiao, T. (2011), “Study on the washability of the Kaitai coal, Guizhou Province China”, Fuel Processing Technology 92, 692-698.
  • [7] Rahman, M., Pudasainee, D. and Gupta, R. (2017), “Review on chemical upgrading of coal: Production processes, potential applications and recent developments”, Fuel Processing Technology 158, 35-56.
  • [7] Rahman, M., Pudasainee, D. and Gupta, R. (2017), “Review on chemical upgrading of coal: Production processes, potential applications and recent developments”, Fuel Processing Technology 158, 35-56.
  • [8] Falconer, A. (2003), “Gravity separation: Old technique/New methods”, Physical Separation in Science and Engineering 12.1, 31-48.
  • [8] Falconer, A. (2003), “Gravity separation: Old technique/New methods”, Physical Separation in Science and Engineering 12.1, 31-48.
  • [9] Lee, S-J., Cho, H-C., and Kwon, J-H. (2012), “Beneficiation of coal pond ash by physical separation techniques”, Journal of Environmental Management 104, 77-84.
  • [9] Lee, S-J., Cho, H-C., and Kwon, J-H. (2012), “Beneficiation of coal pond ash by physical separation techniques”, Journal of Environmental Management 104, 77-84.
  • [10] İbrahim, S.S., Anadoly, B.E., Farahat, M.M., Selim, A.Q., and Menshawy, A.H. (2014), “Separation of pyritic sulfur from Egyptian coal using Falcon concentrator”, Particulate Science and Technology 32, 588-594.
  • [10] İbrahim, S.S., Anadoly, B.E., Farahat, M.M., Selim, A.Q., and Menshawy, A.H. (2014), “Separation of pyritic sulfur from Egyptian coal using Falcon concentrator”, Particulate Science and Technology 32, 588-594.
  • [11] Xia, W., Xie, G. and Peng, Y. (2015), “Recent advances in beneficiation for low rank coals”, Powder Technology 277, 206-221.
  • [11] Xia, W., Xie, G. and Peng, Y. (2015), “Recent advances in beneficiation for low rank coals”, Powder Technology 277, 206-221.
  • [12] Özgen, S., Malkoç, Ö., Doğancik, C., Sabah, E. and Oruç Şapçi, F. (2011), “Optimization of a Multi Gravity Separator to produce clean coal from Turkish lignite fine coal tailings”, Fuel 90.4, 1549-1555.
  • [12] Özgen, S., Malkoç, Ö., Doğancik, C., Sabah, E. and Oruç Şapçi, F. (2011), “Optimization of a Multi Gravity Separator to produce clean coal from Turkish lignite fine coal tailings”, Fuel 90.4, 1549-1555.
  • [13] Honaker, R.Q., Wang, D. and Ho, K. (1996), “Application of the Falcon concentrator for fine coal cleaning”, Minerals Engineering 9.11, 1143-1156.
  • [13] Honaker, R.Q., Wang, D. and Ho, K. (1996), “Application of the Falcon concentrator for fine coal cleaning”, Minerals Engineering 9.11, 1143-1156.
  • [14] Honaker, R.Q., Paul, B.C., Wang, D. and Ho, K. Enhanced gravity separation: an alternative to flotation. Proceedings of high efficiency coal preparation: an international symposium. Colorado (USA): 1995; 70-80.
  • [14] Honaker, R.Q., Paul, B.C., Wang, D. and Ho, K. Enhanced gravity separation: an alternative to flotation. Proceedings of high efficiency coal preparation: an international symposium. Colorado (USA): 1995; 70-80.
  • [15] Rath, R.K., Singh, R. and Bhattacharya, K.K. Processing of coal waste by enhanced gravity separation and froth flotation. Proceedings of International Conference on Coal and Coke. 2011 April 7-8; Jamshedpur (India): 2011; 1-8.
  • [15] Rath, R.K., Singh, R. and Bhattacharya, K.K. Processing of coal waste by enhanced gravity separation and froth flotation. Proceedings of International Conference on Coal and Coke. 2011 April 7-8; Jamshedpur (India): 2011; 1-8.
  • [16] Das, A., Sarkar, B., Ari, V. and Roy, S. (2010), “Efficient recovery of combustibles from coking coal fines”, Mineral Processing Extraction Metallurgy Rev. 31, 236-249.
  • [16] Das, A., Sarkar, B., Ari, V. and Roy, S. (2010), “Efficient recovery of combustibles from coking coal fines”, Mineral Processing Extraction Metallurgy Rev. 31, 236-249.
  • [17] Özbakir, O., Koltka, S. and Sabah, E. (2017), “Modeling and optimization of fine coal beneficiation by hydrocyclone and multi-gravity separation to produce fine lignite clean coal”, Particulate Science and Technology 35.6, 712-722.
  • [17] Özbakir, O., Koltka, S. and Sabah, E. (2017), “Modeling and optimization of fine coal beneficiation by hydrocyclone and multi-gravity separation to produce fine lignite clean coal”, Particulate Science and Technology 35.6, 712-722.
  • [18] Şahinoğlu, E. (2018), “Cleaning of high pyritic sulfur fine coal via flotation”, Advanced Powder Technology 29, 1703-1712.
  • [18] Şahinoğlu, E. (2018), “Cleaning of high pyritic sulfur fine coal via flotation”, Advanced Powder Technology 29, 1703-1712.
  • [19] Ghadyani, A., Noaparast, M. and Tonkaboni, S.Z.S. (2018), “A study on the effects of ultrasonic irradiation as pretreatment method on high-ash coal flotation and kinetics”, International Journal of Coal Preparation and Utilization 38.7, 374-391.
  • [19] Ghadyani, A., Noaparast, M. and Tonkaboni, S.Z.S. (2018), “A study on the effects of ultrasonic irradiation as pretreatment method on high-ash coal flotation and kinetics”, International Journal of Coal Preparation and Utilization 38.7, 374-391.
  • [20] Peng, Y., Mao, Y., Xia, W. and Li, Y. (2018), “Ultrasonic flotation cleaning of high-ash lignite and its mechanism”, Fuel 220, 558-566.
  • [20] Peng, Y., Mao, Y., Xia, W. and Li, Y. (2018), “Ultrasonic flotation cleaning of high-ash lignite and its mechanism”, Fuel 220, 558-566.
  • [21] Özkan, S.G. (2017), “Further investigations on simultaneous ultrasonic coal flotation”, Minerals 7.177, 1-9.
  • [21] Özkan, S.G. (2017), “Further investigations on simultaneous ultrasonic coal flotation”, Minerals 7.177, 1-9.
  • [22] Elbeyli, İ.Y. and Pişkin, S. (2006), “Combustion and pyrolysis characteristics of Tunçbilek lignite”, Journal of Thermal Analysis and Calorimetry 83.3, 721-726.
  • [22] Elbeyli, İ.Y. and Pişkin, S. (2006), “Combustion and pyrolysis characteristics of Tunçbilek lignite”, Journal of Thermal Analysis and Calorimetry 83.3, 721-726.
  • [23] Feng, J., Li, W-Y. and Xie, K-C. (2006), “Thermal decomposition behaviors of lignite by pyrolysis-FTIR”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 28, 167-175.
  • [23] Feng, J., Li, W-Y. and Xie, K-C. (2006), “Thermal decomposition behaviors of lignite by pyrolysis-FTIR”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 28, 167-175.
  • [24] Lievens, C., Ci, D., Bai, Y., Ma, L., Zhang, R., Chen, Y.J., Gai, Q., Long, Y. and Guo, X. (2013), “A study of slow pyrolysis of one low rank coal via pyrolysis-GC/MS”, Fuel Processing Technology 116, 85-93.
  • [24] Lievens, C., Ci, D., Bai, Y., Ma, L., Zhang, R., Chen, Y.J., Gai, Q., Long, Y. and Guo, X. (2013), “A study of slow pyrolysis of one low rank coal via pyrolysis-GC/MS”, Fuel Processing Technology 116, 85-93.
  • [25] Abakay Temel, H., Majumder, A.K. (2016), “Investigation of the effectiveness of desliming and flotation in cleaning Malatya-Arguvan lignite”, Energy Sources, Part A: Recovery, Utilization and Environmental Effects 38, 1048-1054.
  • [25] Abakay Temel, H., Majumder, A.K. (2016), “Investigation of the effectiveness of desliming and flotation in cleaning Malatya-Arguvan lignite”, Energy Sources, Part A: Recovery, Utilization and Environmental Effects 38, 1048-1054.
  • [26] Aksoğan Korkmaz, A. and Bentli, İ. (2017), “Determination of washability characteristics of Arguvan-Malatya lignite by different washability index methods”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 39.14, 1572-1580.
  • [26] Aksoğan Korkmaz, A. and Bentli, İ. (2017), “Determination of washability characteristics of Arguvan-Malatya lignite by different washability index methods”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 39.14, 1572-1580.
  • [27] Birinci, M. Determination of washability characteristics of Parcikan (Malatya) lignite. Proceedings of the 17th International Coal Preparation Congress. 2013 October 1-6; İstanbul (Turkey): 2013; 189-192.
  • [27] Birinci, M. Determination of washability characteristics of Parcikan (Malatya) lignite. Proceedings of the 17th International Coal Preparation Congress. 2013 October 1-6; İstanbul (Turkey): 2013; 189-192.
  • [28] Abakay Temel, H., Majumder, A.K. and Bakir, Y. (2015), “An assessment of Malatya-Arguvan lignite and Southeastern Anatolia region lignites (Turkey)”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 37, 1202-1209.
  • [28] Abakay Temel, H., Majumder, A.K. and Bakir, Y. (2015), “An assessment of Malatya-Arguvan lignite and Southeastern Anatolia region lignites (Turkey)”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 37, 1202-1209.
  • [29] Ünlü, M. The washability characteristics and washing possibilities of Turkish lignites. Proc. 3rd. International Mineral Processing Symposium. 1990 September 11-13; İstanbul (Turkey): 1990; 274-286.
  • [29] Ünlü, M. The washability characteristics and washing possibilities of Turkish lignites. Proc. 3rd. International Mineral Processing Symposium. 1990 September 11-13; İstanbul (Turkey): 1990; 274-286.
  • [30] Wills, B.A. (2007), Mineral Processing Technology 4thEd. Pergamon Press., NewYork, USA.
  • [30] Wills, B.A. (2007), Mineral Processing Technology 4thEd. Pergamon Press., NewYork, USA.
  • [31] Laskowski, J.S. (2001), Coal Flotation and Fine Coal Utilization. Elsevier, Canada.
  • [31] Laskowski, J.S. (2001), Coal Flotation and Fine Coal Utilization. Elsevier, Canada.
  • [32] Altun, N.E. and Hiçyilmaz, C. Evaluation of Alpagut-Dodurga waste coals. Proceedings of the 13th Turkish Coal Congress. 2002 May 29-31; Zonguldak (Turkey): 2002; 113-123.
  • [32] Altun, N.E. and Hiçyilmaz, C. Evaluation of Alpagut-Dodurga waste coals. Proceedings of the 13th Turkish Coal Congress. 2002 May 29-31; Zonguldak (Turkey): 2002; 113-123.
  • [33] Öney, Ö., Tanriverdi, M. and Çiçek, T. Enrichment of Zonguldak fine coals with spiral separator. Proceedings of the 19th Turkish Coal Congress. 2014 May 21-23; Zonguldak (Turkey): 2014; 217-225.
  • [33] Öney, Ö., Tanriverdi, M. and Çiçek, T. Enrichment of Zonguldak fine coals with spiral separator. Proceedings of the 19th Turkish Coal Congress. 2014 May 21-23; Zonguldak (Turkey): 2014; 217-225.
  • [34] Can, M.F., Özgen, S. and Sabah, E. A study to recover coal from Turkish lignite fine coal tailings: comparison of Falcon concentrator and multi gravity separator. International Pittsburgh Coal Conference. 2010 October 11-14; İstanbul (Turkey): 2010; 1897-1912.
  • [34] Can, M.F., Özgen, S. and Sabah, E. A study to recover coal from Turkish lignite fine coal tailings: comparison of Falcon concentrator and multi gravity separator. International Pittsburgh Coal Conference. 2010 October 11-14; İstanbul (Turkey): 2010; 1897-1912.
  • [35] Oruç, F., Özgen, S. and Sabah, E. (2010), “An enhanced-gravity method to recover ultra-fine coal from tailings: Falcon concentrator”, Fuel 89, 2433-2437.
  • [35] Oruç, F., Özgen, S. and Sabah, E. (2010), “An enhanced-gravity method to recover ultra-fine coal from tailings: Falcon concentrator”, Fuel 89, 2433-2437.
  • [36] Boylu, F. (2013), “Modeling of free and hindered settling conditions for fine coal beneficiation through a Falcon concentrator”, International Journal of Coal Preparation and Utilization 33, 277-289.
  • [36] Boylu, F. (2013), “Modeling of free and hindered settling conditions for fine coal beneficiation through a Falcon concentrator”, International Journal of Coal Preparation and Utilization 33, 277-289.
  • [37] Boylu, F. (2014), “Autogenous medium fine coal washing through Falcon concentrator”, Separation Science and Technology 49, 627-633.
  • [37] Boylu, F. (2014), “Autogenous medium fine coal washing through Falcon concentrator”, Separation Science and Technology 49, 627-633.
  • [38] Zhu, X., Tao, Y and Sun, Q. (2017a), “Separation of flocculated ultrafine coal by enhanced gravity separator”, Particulate Science and Technology 35.4, 393-399.
  • [38] Zhu, X., Tao, Y and Sun, Q. (2017a), “Separation of flocculated ultrafine coal by enhanced gravity separator”, Particulate Science and Technology 35.4, 393-399.
  • [39] Honaker, R.Q. (1998), “High capacity fine coal cleaning using an enhanced gravity concentrator”, Minerals Engineering 11.12, 1191-1199.
  • [39] Honaker, R.Q. (1998), “High capacity fine coal cleaning using an enhanced gravity concentrator”, Minerals Engineering 11.12, 1191-1199.
  • [40] Honaker, R.Q., Singh, N. and Govindarajan, B. (2000), “Application of dense-medium in an enhanced gravity separator for fine coal cleaning”, Minerals Engineering 13.4, 415-427.
  • [40] Honaker, R.Q., Singh, N. and Govindarajan, B. (2000), “Application of dense-medium in an enhanced gravity separator for fine coal cleaning”, Minerals Engineering 13.4, 415-427.
  • [41] Tao, Y., Luo, Z., Zhao, Y. and Tao, D. (2006), “Experimental research on desulfurization of fine coal using an enhanced centrifugal gravity separator”, J.China Univ. of Mining and Technology 16.4, 399-403.
  • [41] Tao, Y., Luo, Z., Zhao, Y. and Tao, D. (2006), “Experimental research on desulfurization of fine coal using an enhanced centrifugal gravity separator”, J.China Univ. of Mining and Technology 16.4, 399-403.
  • [42] Zhu, X., Tao, Y., Sun, Q. and Man, Z. (2017b), “Enrichment and migration regularity of fine coal particles in enhanced gravity concentrator”, International Journal of Mineral Processing 163, 48-54.
  • [42] Zhu, X., Tao, Y., Sun, Q. and Man, Z. (2017b), “Enrichment and migration regularity of fine coal particles in enhanced gravity concentrator”, International Journal of Mineral Processing 163, 48-54.
  • [43] Zhu, X., Tao, Y., Sun, Q. and Man, Z. (2017c), “The low efficiency of lignite separation by an enhanced gravity concentrator”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 39.8, 835-842.
  • [43] Zhu, X., Tao, Y., Sun, Q. and Man, Z. (2017c), “The low efficiency of lignite separation by an enhanced gravity concentrator”, Energy Sources Part A: Recovery, Utilization and Environmental Effects 39.8, 835-842.
  • [44] Zhang, L., Tao, Y., Yang, L. and Man, Z. (2017), “Spatial distribution of fine high-sulfur lean coal in enhanced gravity field”, Energy Sources, Part A: Recovery, Utilization and Environmental Effects 39.22, 2098-2104.
  • [44] Zhang, L., Tao, Y., Yang, L. and Man, Z. (2017), “Spatial distribution of fine high-sulfur lean coal in enhanced gravity field”, Energy Sources, Part A: Recovery, Utilization and Environmental Effects 39.22, 2098-2104.
Toplam 88 adet kaynakça vardır.

Ayrıntılar

Birincil Dil İngilizce
Konular Mühendislik
Bölüm Makaleler
Yazarlar

Aydan Aksoğan Korkmaz 0000-0002-3309-9719

Proje Numarası 2015/34
Yayımlanma Tarihi 31 Ağustos 2021
Gönderilme Tarihi 2 Mayıs 2021
Kabul Tarihi 2 Ağustos 2021
Yayımlandığı Sayı Yıl 2021

Kaynak Göster

APA Aksoğan Korkmaz, A. (2021). Determination of the effect of different gravity methods on the removal of ash and sulfur from Arguvan lignite. ALKÜ Fen Bilimleri Dergisi, 3(2), 64-81. https://doi.org/10.46740/alku.931712
AMA Aksoğan Korkmaz A. Determination of the effect of different gravity methods on the removal of ash and sulfur from Arguvan lignite. ALKÜ Fen Bilimleri Dergisi. Ağustos 2021;3(2):64-81. doi:10.46740/alku.931712
Chicago Aksoğan Korkmaz, Aydan. “Determination of the Effect of Different Gravity Methods on the Removal of Ash and Sulfur from Arguvan Lignite”. ALKÜ Fen Bilimleri Dergisi 3, sy. 2 (Ağustos 2021): 64-81. https://doi.org/10.46740/alku.931712.
EndNote Aksoğan Korkmaz A (01 Ağustos 2021) Determination of the effect of different gravity methods on the removal of ash and sulfur from Arguvan lignite. ALKÜ Fen Bilimleri Dergisi 3 2 64–81.
IEEE A. Aksoğan Korkmaz, “Determination of the effect of different gravity methods on the removal of ash and sulfur from Arguvan lignite”, ALKÜ Fen Bilimleri Dergisi, c. 3, sy. 2, ss. 64–81, 2021, doi: 10.46740/alku.931712.
ISNAD Aksoğan Korkmaz, Aydan. “Determination of the Effect of Different Gravity Methods on the Removal of Ash and Sulfur from Arguvan Lignite”. ALKÜ Fen Bilimleri Dergisi 3/2 (Ağustos 2021), 64-81. https://doi.org/10.46740/alku.931712.
JAMA Aksoğan Korkmaz A. Determination of the effect of different gravity methods on the removal of ash and sulfur from Arguvan lignite. ALKÜ Fen Bilimleri Dergisi. 2021;3:64–81.
MLA Aksoğan Korkmaz, Aydan. “Determination of the Effect of Different Gravity Methods on the Removal of Ash and Sulfur from Arguvan Lignite”. ALKÜ Fen Bilimleri Dergisi, c. 3, sy. 2, 2021, ss. 64-81, doi:10.46740/alku.931712.
Vancouver Aksoğan Korkmaz A. Determination of the effect of different gravity methods on the removal of ash and sulfur from Arguvan lignite. ALKÜ Fen Bilimleri Dergisi. 2021;3(2):64-81.

Cited By

Upgrading low-rank lignite coals (Çan, Çanakkale/Turkey) by leaching
International Journal of Coal Preparation and Utilization
https://doi.org/10.1080/19392699.2024.2344817