INVESTIGATION OF THE PERFORMANCE FOR A GAS TURBINE JET ENGİNE BY USING EXERGY ANALYSIS METHOD

Year 2019, Volume: 8 Issue: 1, 405 - 411, 28.01.2019

Cem Tahsin Yücer

https://doi.org/10.28948/ngumuh.517154

Abstract

   This study deals with a gas turbine jet
engine module which was analyzed to investigate its performance at three
different gas turbine speed values. The objectives are: to examine the
thermodynamic processes involved, to determine the theoretical and measured
data for the compressor, the combustion chamber and the gas turbine and to
perform the energy and exergy balances on the jet engine components. The jet
engine can operate up to the120000 rpm. The measured data include pressure,
temperature, air flow rate, fuel flow rate and thrust values. This paper
presents measured experiment data and analytical results of the jet engine.
Since the compressor outlet temperature of the part load-1 is the minimum of
all, it has the minimum work gained from the gas turbine. The exergy
destructions caused by the combustion chamber were the maximum above all system
components. It can be inferred from the analysis that the more loading applied
to the jet engine the more exergy gained from the fuel. However the exergy
efficiencies become lower. They were calculated as 7.1%, 6% and 5.5%,
respectively.

Keywords

Jet engine, Exergy analysis, Energy Analysis, Part load

EKSERJİ ANALİZİ YÖNTEMİ KULLANILARAK BİR GAZ TÜRBİNLİ JET MOTORUNUN PERFORMANS ARAŞTIRMASI

Abstract

   Bu çalışmada bir gaz türbinli jet motorunun
üç farklı devir sayısı için performans analizi yapılmıştır. Çalışmanın amacı
kompresör, yanma odası ve gaz türbini için teorik ve ölçüm sonucu elde edilen
verilerin termodinamik süreçler  dikkate
alınarak incelenmesi ve jet motoru bileşenlerinin enerji ve ekserji
dengelerinin elde edilmesidir. Ele alınan jet motorunun devir sayısı 120.000
d/d değerine kadar artırılabilmektedir. Ölçülen veriler basınç, sıcaklık, hava
akımının debisi, yakıtın debisi ve itki değerleridir. Bu makalede jet motoruna
ait ölçülen verilere ve analitik sonuçlara yer verilmiştir. Birinci kısmi yük
için kompresör çıkış sıcaklığı en düşük olduğu için gaz türbininden elde edilen
iş miktarı da en düşük değerdedir. Yanma odasının ekserji yıkım miktarları üç
farklı yük değerinde de en yüksek değerlerdedir. Jet motorunun çalışma yükü
artırıldıkça yakıttan daha fazla ekserji elde edilmektedir. Buna rağmen ekserji
verimi ise çalışma yükü arttıkça azalmaktadır. Ekserji verimleri sırasıyla
%7.1, %6 ve %5.5 olarak bulunmuştur.

Keywords

Jet motoru, Ekserji analizi, Enerji analizi, Kısmi yük

References

• [1] TURAN, O., Exergetic Effects of Some Design Parameters on The Small Turbojet Engine for Unmanned Air Vehicle Applications, Energy, 46, 51-61, 2012.
• [2] MATTINGLY, J.D., “Elements of Propulsion: Gas Turbines and Rockets”, AIAA Education Series, 2006.
• [3] DINCER, I., ROSEN, M.A., Exergy. Elsevier, 2007.
• [4] TURGUT, E.T., KARAKOC, T.H., HEPBASLI, A., ROSEN, M.A., “Exergy Analysis of a Turbofan Aircraft Engine”, International Journal of Exergy, 6(2), 182-199, 2009.
• [5] TURAN, O., “Exergy and entropy Analyses Of An Experimental Turbojet Engine For Target Drone Application”, Anadolu University Journal Of Science and Technology, 17(5), 936-952, 2016.
• [6] EHYAEI, M.A., ANJIRIDEZFULI, A., ROSEN, M.A., “Exergetic Analysis of an Aircraft Turbojet Engine with an Afterburner”, Thermal Science, 17(4), 1181-1194, 2013.
• [7] BALLI, O., HEPBASLI, A., “Energetic and Exergetic Analysis of T56 Turboprop Engine”, Energy Conversion and Management, 73, 106-120,2013.
• [8] BAHETA, A.T., GILANI, S.I., “Exergy Based Performance Analysis of a Gas Turbine at Part Load Conditions”, Journal of Applied Sciences, (11), 1994-1999, 2011.
• [9] HAYES, D., LONE, M., WHIDBORNE, J.F., CAMBEROS, J., COETZEE, E., “Adopting Exergy Analysis for Use in Aerospace”, Progress in Aerospace Sciences, 93, 73-94, 2017.
• [10] EKİCİ, S., SOHRET, Y., COBAN, K., ALTUNTAS, O., KARAKOC, T.H., “Ssutainability Metrics of a Small Scale Turbojet Engine”, International Journal of Turbo and Jet Engines, 35(2), 113-120, 2018.
• [11] SOHRET, Y., “A Comprehensive Approach to Understanding Irreversibility in a Turbojet”, Propulsion and Power Research, 7(2), 129-137, 2018.
• [12] COBAN, K., SOHRET, Y., COLPAN, C.Ö., KARAKOC , T.H., “Second Law Analysis of an Experimental Micro Turbojet Engine”. In: Aloui F., Dincer I. (eds) Exergy for A Better Environment and Improved Sustainability 1. Green Energy and Technology. Springer, Cham, 2018.
• [13] POURMOVAHED, A., JERUZAL, C.M., BRINKER, K.D., “Development of a Jet Engine Experiment For The Energy Systems Laboratory”, ASME International Mechanical Engineering Congress, Washington D.C., Nov 2003.
• [14] YUCER, C.T., “Thermodynamic Analysis of the Part Load Performance for a Small Scale Gas Turbine Jet Engine by Using Exergy Analysis Method”, Energy, 111, 251-259, 2016.